Technical and Economic Indicators for Operating Irrigation Pump using Natural Gas

Abstract

Hayder A. Shanan, Khaleed F. El Bagoury, Abdullah M. Abdelmaqsoud and Waleed K.ElHelew

This paper presents the experimental for the types of mixers used in mixing natural gas with air to operate the irrigation pump to save energy, many of measurements were carried 2021 year in workshops of Agricultural Engineering Depart- ment, Faculty of Agriculture, Ain Shams University, Egypt. Used engine single-cylinder, air-cooled. A new pump with a discharge diameter of 2 inches, which was an Egyptian manufacture. Several types of mixers were manufactured to mix natural gas with air before entering the engine. Using iron pipes of different diameters, three types of mixers were used Mixer with a perforated inner tube of 8, 10. 12cm (L8, L10, L12) . selected determine the four shaft speeds (1750, 2300, 2900 and 3500 rpm) using the engine speed measuring device. The results here dealt with study the analysis of technical indicators for the types of mixers used in mixing natural gas with air to operate the irrigation pump. where the actual power (Braking power) is superior to all types when operating with gasoline was (3.07 kW) A comparison with the use of natural gas, where the mixer type (L10) (2.69 kW) was 10% less than gasoline. the lowest Specific fuel consumption (s. fc) for gasoline was (219.025 gm/Kw.h) at an engine speed of (2900 rpm), The lowest (S.fc) for the types of mixers was the mixer (L10) was (340.144 gm/Kw.h) at an engine speed of (2900 rpm),The highest pump discharge was with the L8 mixer (32.98 m3/h), an increase of 1.8% over gasoline at an engine speed of (3500 rpm), The highest actual hydraulic power with L10 type mixer compared to other type L mixers (0.782 kW) was 12 % lower than that of gasoline. As for the economic indicators the lowest Internal Rate of Return (IRR) was Gasoline ( 0.44), and the highest (IRR) when carrying the mixer type (L8) was (0.60) an increase of 26.6 % over gasoline. the lowest payback pe- riod was the type of mixer (L8) was (1.66 year), and the highest payback period When the Gasoline it was (2.27 year).

PDF